Tver, Tver, Russian Federation
from 01.01.2015 until now
Tver', Tver, Russian Federation
The work describes the principles of low-energy technology of non-autoclave porous concrete (NAPC) based on fuel ash. After closing with water and mixing in a conventional mixer, the feed mixture is poured into molds or formwork, where it swells and then solidifies under normal conditions or with little heat treatment. The use of NAPC with the same average density as conventional light concretes on roasting aggregates for reinforced bearing structures can be justified by the close values of the total porous steel and the associated elastic and deformative properties, as well as similar working conditions of reinforcement in these products. At the same time, compared to gas-ozone concrete, NAPC is advantageously characterized by greater stability of properties during manufacture, lower consumption of ha-z-forming additives, and compared to conventional light concrete — the absence of expensive large porous aggregates. Strength and deformation characteristics of NAPC are determined both at short-term and long-term active loads, which is the basis for further research on the use of this per -special material in bearing and enclosing structures.
non-autoclave gas concrete, fuel ash as filler, low-energy technology, strength and deformation characteristics
1. Chinenkov Yu.V., Yarmakovsky V.N. Light concretes and structures of them. Concrete and reinforced concrete. 1997. N 5. P. 8-10 (in Russian).
2. Chernyshov E.M., Slavcheva G.S., Potamoshneva N.D., Makeev A.I. Porous concrete for heat-efficient residential buildings. Izv. vuzov. Stroitel'stvo. 2002. N 5. P. 22-27 (in Russian).
3. Leonovich S.N., Sviridov D.V., Schukin G.L, Belanovich A.L., Karpushenkov S.A., Savenko V.P. Foam concrete shrinkage compensation. Stroitel'nye Materialy. 2015. N 3. P. 3-7 (in Russian).
4. Svinarev A.V., Glushkov A.M., Kuprina A.A. Technological module TM-25 for the production of non-autoclaved fibropene concrete products. Stroitel'nye Materialy. 2014. N 6. P. 4-7 (in Russian).
5. Berdov G.I., Elesin M.A., Umnova E.V. Cellular slag-portland cement betone on a lime-sulfur gate. Stroitel'nye Materialy. 2015. N 5. P. 74-76 (in Russian).
6. Loganina V.I., Makarova L.V., Sergeeva K.A. Properties of lime composites with silicate-containing fillers. Stroitel'nye Materialy. 2012. N 3. P. 30-31 (in Russian).
7. Selyaev V.P., Neverov V.A., Mashtaev O.G., Sidorov V.V. Microstructure thermal insulation materials na osnove fine mineral powders. Stroitel'nye Materialy. 2013. N 8. P. 79-80 (in Russian).
8. Yang Lin, Yan Yun and Hu Zhihua. Utilization of phosphogypsum for the preparation of non-autoclaved aerated concrete. Construction and Building Materials. 2013. V. 44. P. 600–606.
9. Piasta Wojciech, Sikora Hubert. Effect of airentrain menton shrinkage of blended cements concretes. Construction and Building Materials. 2015. V. 99. P. 298–307.
10. Saraikina K.A., Golubev V.A., Yakovlev G.I., Senkov S.A., Politaeva A.I. Nanostructure-bath of cement stone with dispersed reinforced basalt in-locna. Stroitel'nye Materialy. 2015. Vyp. 2. P. 34-38 (in Russian).
11. Saye D. Reduction Methods Shrinkage Deformation Concrete. Cement and its applications. 2016. N 5. P. 64-67 (in Russian).
12. Smirnova P.V., Morgun L.V., Morgun V.N. Theoretical and experimental justification of the possibility of controlling the amount of shrinkage strains in foam concrete of non-autoclave hardening. Stroitel'nye Materialy. 2013. N 4. P. 96-98 (in Russian).
13. Efimenko A.Z. Non-autoclave gas concrete on sand from concrete crushing waste. Stroitel'nye Materialy. 2009. N 1. P. 13 (in Russian).
14. Yakimechko Y.B. Non-autoclave gas concrete with polydisperse fillers based on industrial waste. Stroitel'nye Materialy. 2009. N 1. P. 24-26 (in Russian).
15. Silaenkov E.S. Prospects for the production and use of nonnuclear gas concrete products in the Urals. Beton i zhelezobeton. N 1. 1996. P. 2-5 (in Russian).
16. Akhmanitsky G.Ya., Bessilniy T.P., Bekisheva L.K. Ways to improve technology and equipment for the production of products from non-autoclaved cellular concrete. Beton i zhelezobeton. 1997. Vyp. 2. P. 9-12 (in Russian).
17. Prokopovich I.E., Zedgenidze V.A. Applied theory of crawlverse. M.: Stroyizdat. 1980. 240 p. (in Russian).
